中科混凝土攪拌機的規范操作你了解嗎?
如何規范中科混凝土攪拌機的操作?混凝土攪拌機的準備
How to standardize the operation of concrete mixers in Zhongke? Preparation of concrete mixers
1.檢查攪拌機是否穩定，四個支撐腿是否牢固;
1. Check whether the mixer is stable and whether the four support legs are firm;
2.機器運轉是否正常;
2. Whether the machine operates normally;
3.水泵注分流水，試車一次;
3. The water pump shall be injected with separate water and tested once;
4.檢查電器的接地。
4. Check the grounding of electrical appliances.
二、混凝土攪拌機的使用要求
2、 Requirements for use of concrete mixer
1.每次添加的混合料不得超過規定值，料斗必須在混合完成后才能抬起進料;
1. The mixture added each time shall not exceed the specified value, and the hopper can only lift the feed after mixing;
2.滾筒反轉時千萬不要提起手柄;
2. Do not lift the handle when the roller reverses;
3.為了減少粘鍋現象，在進料斗時，優先順序為砂礫—水泥—砂或砂—水泥—石;
3. In order to reduce the phenomenon of boiler sticking, the priority of feeding hopper is gravel cement sand or sand cement stone;
4.加料時及時加水，縮短攪拌時間，減少粉塵;
4. Add water in time when feeding, shorten mixing time and reduce dust;
5.當料斗升起時，任何人不得在料斗下停留或通過;當必須在料斗下進行維修時，料斗應用安全鏈固定。
5. When the hopper is raised, no one is allowed to stay or pass under the hopper; when maintenance must be carried out under the hopper, the hopper shall be fixed with safety chain.
6.非操作人員不得翻轉控制手柄;機器不運轉時，一定要用安全鉤把機器固定好;
6. Non operators shall not turn over the control handle; when the machine is not running, it must be fixed with a safety hook;
7.注意電器的安全，經常檢查接地是否良好，防止電機受潮，防止電器元件、電線的損壞;
7. Pay attention to the safety of electrical appliances, regularly check whether the grounding is good, prevent the motor from getting damp, and prevent the damage of electrical components and wires;
8.斷電時，用曲柄搖撼減速機帶板，將筒內物料排出;
8. When the power is cut off, shake the belt plate of the reducer with the crank to discharge the materials in the barrel;
9.停車時，必須放下四個支撐腳管來支撐機器的重量;
9. When parking, four support legs must be put down to support the weight of the machine;
三、混凝土攪拌機完成工作的要求
3、 Requirements for completion of concrete mixer
1.停機前，應將一定數量的石子和水放入機器中，攪拌5 ~ 10分鐘，然后釋放，以消除氣缸內的積存，避免粘在水箱上;
1. Before shutdown, a certain amount of stones and water shall be put into the machine, stirred for 5 to 10 minutes, and then released to eliminate the accumulation in the cylinder and avoid sticking to the water tank;
2.清除混凝土上的積灰和粘結劑;
2. Remove the ash and binder on the concrete;
3.將料斗置于運輸位置，懸掛安全鏈;控制手柄用安全鉤固定;
3. Place the hopper in the transportation position and hang the safety chain; fix the control handle with the safety hook;
4.切斷電源，鎖好電箱;
4. Cut off the power supply and lock the electric box;
5.在冰凍季節，將供水系統的所有積水全部排放;
5. In the freezing season, discharge all the accumulated water in the water supply system;
6.在每個潤滑點加注必要的潤滑油。
6. Add necessary lubricating oil at each lubricating point.
以上是中科混凝土攪拌機廠家為大家介紹的相關內容，想要了解更多內容，歡迎訪問網站：http://www.xiaoplaoshi.cn
The above is the relevant content introduced by the concrete mixer manufacturer of China Science and Technology Co., Ltd. for more information, please visit the website: http://www.xiaoplaoshi.cn
